Update to the shower leak, bedroom door and ac shroud.
The shower still leaked but, after a little investigation, I found there was no caulking at the point where the front vertical rail meets the horizontal rail. Probably a 1/2 gap and no caulking. After a shower, a simple push on the horizontal rail would produce quite a bit of water. A considerable amount of clear RTV sealed it up.
The door is another issue. I need to reset the mirror frame and square it up before using some gorilla glue so it will not come out again.
The AC shroud is a different story. The service manager all but accused us of breaking the shroud ourselves in the ten mile drive to the RV park. He kept saying that they inspect a unit on receipt top to bottom, end to end with a thorough checklist. I don't believe in loosing my cool will do anything so I asked him that if it were true, how did they miss the entry door being difficult to open or latch, the bedroom door not latching, the closet doors not sliding easily at all, the fender skirt braces not being attached, etc. Naturally, he glossed over it but said he would check their "EWO" checklist... A few days later, he calls back and literally mumbles an apology and said it was noted on the "EWO" after all and they failed to have it fixed.. Now, they faxed the inspection to my local dealer who will do the warranty work.
The only other issue that has cropped up is the LP side of the water heater is DOA. DSI did spark for a while but she's dead Jim.. It'll be handled when AC shroud is replaced.
We sit and enjoy the beauty and comfort of this rig. It is a joy to relax in and just look around or listen to a bit of music. I was surprised that there is a sub woofer located behind the fireplace now since I'd read several posts complaining of no sub.